鍋爐除塵器運行時的注意事項

鍋爐除塵器（作用：凈化空氣）是當前治理環境(environment)的主力軍,其應用范圍(fàn wéi)及其廣泛(extensive),從風量（定義：單位時間內空氣的流通量）一千的到幾十萬的工況,大部分都是采用了布袋鍋爐除塵器,那么它在新運行時應注意(attention)的事項如下:

Boiler dust collector is the main force of the current governance environment, its scope of application and wide, from the air a thousand to hundreds of thousands of conditions, most of them are the boiler bag type dust remover, it in the new operation should pay attention to the matters are as follows:
1、處理(chǔ lǐ)風量（定義：單位時間內空氣的流通量）和各測試（TestMeasure)點壓力與溫度是否與設計相符合.
1, the tre自動取款機ent of air flow and the test point pressure and temperature is consistent with the design.
2、風機（Draught Fan）的旋轉方向、轉速、軸承(bearing)振動和溫度（temperature).
2, the rotation direction of the wind turbine, speed, bearing vibration and temperature.
3、工作(gōng zuò)人員也要注意(attention)袋室結露情況(Condition)是否存在,排灰系統(system)是否暢通.防止阻塞和腐蝕發生,積灰嚴重時會影響主機的生產(Produce).
3, the staff to bag room conden學術能力評估測試ion is there, rows of grey system is smooth. To prevent the occurrence of blockage and corrosion, serious ash deposition will influence a host of production.
4、清灰(qīng huī)周期及清灰時間的調整,這項工作是左右捕塵性能和運轉狀況的重要因素(factor).清灰時間過長,將使附著粉塵（形態：固體微粒）層被清落掉,成為鍋爐除塵器（作用：凈化空氣）除塵布袋泄漏和破損的原因.如果清灰時間過短,除塵布袋上的粉塵尚未清落掉,就恢復過濾作業,將使阻力(zǔ lì)很快地恢復并逐漸增高起來,終影響其使用效果.
4, cleaning cycle and cleaning time of adjustment, this work is about catching dust performance and operating status of the important factors. Cleaning time is too long, will enable the attachment of dust layer is pure to fall off and become boiler GOOGLE PRecipitator dust bag leakage and breakage reasons. If the cleaning time is too short, dust bag dust is not clear to fall, on the restoration of the filtering operation, will enable the resistance quickly recovered and increased gradually up, and ultimately affect the effect of its use.
5、鍋爐(guō lú)除塵器的安裝情況(Condition),在使用后是否有掉袋、松口、磨損（零部件失效的一種基本類型）等情況發生,投運后可目測煙囪的排放情況來判斷.
5, boiler precipitator installation, in use is off the bag, Tricholoma, wear, put into operation can visually chimney emissions to judge.

脈沖除塵器有哪些強大的凈化效率

脈沖布袋除塵器也稱（作用：凈化空氣）有哪些強大的凈化效率 脈沖布袋除塵器也稱（作用：凈化空氣）極高的凈化效率&mdash;對于0.2&mu;m以上的粉塵（形態：固體微粒），效率高達99.99%以上，排放濃度<1mg/m3;穩定的阻力-PTFE微孔涂膜先進制造技術，使除塵過程實現了表面過......

脈沖除塵器有良好的密封性能

現在，環境感染日益嚴重，在環境保護方面也抓得越來越嚴，對于環保不達標的公司(Company)給予了嚴厲的處理(chǔ lǐ)，針對這種情況(Condition)，我公司也研究（research)了現在的脈沖布袋除塵器也稱（作用：凈化空氣）行業的設備(sh&egrave;b&egrave;i)現狀，對現有的除塵設備(......

脈沖除塵器應用越來越多

脈沖除塵器（作用：凈化空氣）是現代除塵設備(sh&egrave;b&egrave;i)中使用較為頻繁（frequency)的一種除塵器，是指通過(tōng gu&ograve;)噴吹壓縮空氣的方法除掉過濾材料(Material)上（布袋或?yàn)V筒）上附著的粉塵（形態：固體微粒）；根據除塵器的大小可能（maybe)有幾組脈......

脈沖除塵器損壞的主要原因

除塵器（作用：凈化空氣）布袋損壞的主要原因 除塵器（作用：凈化空氣）布袋主要損壞原因一般有以下幾點： 一、過濾風速 布袋除塵器也稱的過濾風速過高，是除塵器布袋損壞的主要原因。近年來，有些單位(unit)盲目（眼睛看不見東西、比喻認識不清)的降低（reduce)設備......